Mallory-ignition Mr_Gasket ELECTRIC (MICRO) DIESEL FUEL PUMP 12D Manuel d'utilisateur télécharger pdf

MR. GASKET 1www.mr-gasket.com

GENERAL INFORMATION

The Mr. Gasket (Micro) Electric Fuel Pump #12D is a gravity

feed pump designed for use with diesel applications, either

as a stand alone, booster or fuel transfer pump. Pump is

self-priming, with a two bolt and two wire installation. Aver-

age 2 amp draw at maximum delivery. Operating fuel pres-

sure range for is 4 – 7 PSI and ﬂow is 35 GPH.

MOUNTING PROCEDURE

Step 1

Make sure the fuel tank is very close to empty. Drain if

needed. Inspect the current fuel line – if it is cracking, re-

place it with a new fuel rated hose. Install supplied in-line

ﬁlter to prevent small particles from entering the pump.

We highly recommend installing a ﬁlter as well between

the carburetor and fuel pump to prevent small particles

from entering the carburetor. If you choose to no longer

use your mechanical fuel pump, make sure to install a

block-off plate or plug the pump inlet and outlets. All fuel

line connections should be leak-proof.

Step 2

Mount the pump about 12” from the fuel tank and as close

to the lowest level of the tank to ensure proper fuel sup-

ply. Refer to Figure 1. Make sure mounting area is clean

of all rust, paint and grease.

Step 3

Using the pump mounting bracket as a template, drill two

7/32” holes. Next, use the supplied self-tapping bolts and

star washers to secure the pump and ground lead to the

frame. Always mount the pump in a location that allows

you to add the safety nuts provided. Install the supplied

ﬁlter in the pump inlet and install outlet ﬁtting using thread

sealer and tighten to 10-ft-lbs. NOTE: Never install pump

in engine compartment.

Step 4

Attach the hose to the inlet side of the supplied ﬁlter using

automotive quality hose clamps. Some tank outlets may

have 3/8” instead of the supplied 5/16” ﬁttings. You may

need to purchase one 3/8” barb x 1/8” NPT x 3/8” length.

If using 3/8” ﬁtting, you may need to purchase a 3/8” ﬁlter.

DO NOT USE PUMP WITHOUT A FILTER. Install the

correct size fuel line from the outlet port on the fuel pump

to the factory metal fuel line going to the engine bay. If

no fuel line exists, fabricate a hard line from the pump to

the engine compartment. NOTE: Never run rubber fuel

line from the rear of the vehicle to the front. Always

minimize use of rubber hose. When possible, use steel

hard line.

Step 5

Make sure to use the red lead for 12 Volt power (fused

5 amp max) and the black lead for ground. The red

positive lead needs to be connected to the switched

ignition terminal. Use a 5 amp fuse or in-line fuse holder.

Use only automotive grade electrical cable - minimum

16 gauge. If wire is run over 20 feet, use 14 gauge.

Ensure that all connections are secured and sealed

from the elements. NOTE: This pump is for negative

ground systems only.

INSTALLATION INSTRUCTIONS

(MICRO) ELECTRIC DIESEL FUEL PUMP – Mr. Gasket Part No. 12D

FORM 12D2012-REV2

READ ALL INSTRUCTIONS CAREFULLY BEFORE BEGINNING INSTALLATION. FOR NEGATIVE GROUND SYSTEMS ONLY. NOT FOR USE

WITH FUEL INJECTED SYSTEMS, HIGH PERFORMANCE OR MODIFIED ENGINES, AIRCRAFT OR MARINE APPLICATIONS.

FIGURE 1:

1 2 3 4

Résumé du contenu

Page 1 - INSTALLATION INSTRUCTIONS

MR. GASKET 1www.mr-gasket.comGENERAL INFORMATION The Mr. Gasket (Micro) Electric Fuel Pump #12D is a gravity feed pump designed for use with diesel ap

Page 2 - MR. GASKET 2

MR. GASKET 2www.mr-gasket.comStep 6Inspect and tighten all connections before start up. Turn the key to the on position to prime, and leave on for 10

Page 3 - INSTRUCCIONES DE INSTALACIÓN

MR. GASKET 3www.mr-gasket.comINFORMACIÓN GENERALLa bomba de combustible (micro) eléctrica Mr. Gasket N.º 12D es una bomba alimentada por gravedad dise

Page 4 - MR. GASKET 4

MR. GASKET 4www.mr-gasket.comMR. GASKET IS A TRADEMARK OF PRESTOLITE PERFORMANCE10601 Memphis Ave. #12, Cleveland, OH 44144216.688.8300 FAX 216.

Commentaires sur ces manuels

Pas de commentaire

Mallory-ignition Mr_Gasket ELECTRIC (MICRO) DIESEL FUEL PUMP 12D Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Mallory-ignition Mr_Gasket ELECTRIC (MICRO) DIESEL FUEL PUMP 12D. Mallory Ignition Mr_Gasket ELECTRIC (MICRO) DIESEL FUEL PUMP 12D User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la voiture Mallory-ignition Mr_Gasket ELECTRIC (MICRO) DIESEL FUEL PUMP 12D